Pro-Line Boats Dual Console Series Manual do Proprietário

2009 23 DUAL CONSOLE Owner’s Manual Specifications subject to change without notice. Actual boats may vary from drawings and/or photos. Copyrigh

We highly recommend that you add a protective coating to your hull. Find out which type of bottom paint is recommended for your area and have an epox

5Safety Your Pro-Line boat has been constructed with safety in mind. But, remember, boating safety and the safety of your passengers is YOUR ultim

• Shut off potential sources of CO, if possible. Correct ventilation problems and/or repair exhaust problems as appropriate. Investigate the source

7“teak” swim platform of a vessel while a wake builds up then lets go to body surf on the wave created by the boat; hence the term - Teak Surfing.)

8 • Damage to the hull or thru-hull fitting • Waves washing into the boat • Water entering cockpit due to improper loading • Failure to properly

9 The information here is only a “brief” overview. Please contact the USCG for detailed information. • Audible warning signals: o One short horn

Controls Controls and engine systems vary greatly from one engine manufacturer to another. Please read your engine owner’s manual carefully. Note:

11 The throttle lever has three range positions: “Forward”, “Neutral”, and “Reverse”. The shift function occurs in the first portion of the lever t

Trim Tabs (Optional) The trim tabs come equipped with auto retract. The planing tabs are located on each side of the transom on the bottom of the hu

Systems and Accessories Electrical System 12 Volt Receptacle (Optional) The 12-volt receptacle is installed on the console. It is easily accessib

ii

14o If you have Faria gauges on the dash panel, this function will illuminate the gauge lights. o If the gauges were provided by the engine manufac

To test the operations of the battery switch, place the switch in the off position and try to start up the engine(s). When the switch is off, you sho

Using different sequences of horn blasts indicates different and sometimes dangerous situations to you or someone around you. See the Safety Section

17trim of the engine. When finished trimming the engine all the way up, the level on the trim gauge should read in the full up position. Volts - To

Inspect all hose connections on a regular basis. You can access the fuel fill and fuel vent via the deck plate that is installed next to the binnacle

19Please refer to the owner’s manual provided by your engine manufacturer for proper procedures. Some engines will not have a separate fuel water se

When you turn off the cockpit shower faucet, the pump may run briefly. If the pump continues to run with all faucets closed, check the system for le

Second, turn the bilge pump off at the instrument panel and check the bilge pump float switch. The bilge pump is equipped with an automatic float swi

If you find it necessary to run the baitwell pump while you are underway, you may be forcing more water than necessary up through the seacock. In thi

23service and/or warranty repairs must be performed by a repair facility that is authorized to work on their equipment. Windshield The windshield a

iii Table of Contents Page Introduction Specifications...

Drain fitting for starboard casting deck storage box via access pie inside the starboard console storage area Anchor LockerGlove boxFuel fill &

Hand Rails Bow Rail - The low profile bow rail is constructed of stainless steel. The railing, which is through bolted to the gunwale, is provided fo

Gunwale Trim / Rubrail A white rigid vinyl gunwale trim with a stainless steel insert is installed at the juncture of the deck and hull. This durabl

27Arch (Optional) The arch, made of powder-coated aluminum, is mounted over the console. This sleek looking arch includes a set of four rocket laun

Operation and Performance Trim / Tilt The power trim system allows the operator to raise and lower the motor(s) throughout an infinite number of se

it may be desirable to re-prop your Pro-Line to enhance the desired performance needs for your area. For instance: • Decreasing the pitch will enha

30• Close doors and hatches so fumes do not enter boat. • Disembark all persons not necessary for the fueling operation. • Prohibit all smoking an

Trailering and Launching Selecting A Trailer Choose the proper trailer for your boat and make sure the trailer you use is certified. Consult your

• The safety chains are attached crisscrossing under the coupler to the frame of the tow vehicle. If the ball were to break, the trailer would fol

33• Verify that your safety equipment is aboard. • Raise the lower unit (remove supports) to the proper height for launching so that it will not hi

iv Page Cockpit Lights (Optional)... 15 Navigation /

34Service and Care To enjoy trouble free use of your Pro-Line, follow the recommended procedures and instructions relating to the service and care

35 Antifouling bottom paint is designed to dissolve slowly to prevent marine growth. Therefore, the hull bottom should be repainted at the beginning

36dome. This will in no way affect the reading or accuracy. When restored to normal temperature, the air bubble will disappear. Clean the Lucite c

37metals, stainless will discolor, rust or even corrode. The degree of surface oxidation is directly affected by local atmosphere and saltwater conc

38windshield manufactured recommends LanoCote, which is commercially available at West Marine. • When washing the powder-coated surface, use fresh w

39becoming deeply imbedded in the fabric and eliminate the need for more frequent vigorous cleanings. In most environments, a thorough cleaning will

40surfaces. For stubborn stains, use either Fantastic or Mr. Clean, which are commercially available mild detergents, in accordance with manufacture

41 • Cleats • Rubrail • Thru hull fittings • Bow rail stanchions • Access and other hatches • Ladder • T-top stanchions and supports • W

42 Appendix Helpful Check Lists Print and use these checklists, and do not operate your boat without doing the following: Each Time You Go On a

43 Boat Identification Information Owner: Home Port: Dealer: Boat Name: Registration Number: Hull ID Number: Boat Model: LOA: Bea

v Page Operation and Performance Trim / Tilt...

44Trouble Shooting Chart PROBLEM: POSSIBLE CAUSE Poor speed or fuel economy: Wrong propeller for load or conditions. Trim is in too far. Load is t

vi Page Appendix Helpful Check Lists...

1Introduction Congratulations on the purchase of your new Pro-Line Boats 23 Dual Console sport fishing boat. Welcome into the proud family of sati

Dealer Responsibilities Your dealer's responsibilities include but are not limited to: • Pre-delivery verification of proper rigging and opera

3Make sure that you complete the individual warranty cards for these products and forward them on to the respective manufacturers to register for you